Product ID:INSULGREASE SG 194, 76156
MSDS Date:03/30/1999
FSC:8030
NIIN:00N093071
Status Code:A
MSDS Number: CJWTD

Emergency Phone: (800)424-9300

Info Phone: 973-403-2600

Preparer: J. HERMELE

Cage: 88444

Telephone: 973-403-2600

Cage: 88444

POLYDIMETHYLSILOXANES

CAS: 63148-62-9

RTECS: JT6484500

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE OVEREXPOSURE: IRRITANT TO SKIN,
EYES AND RESPIRATORY TRACT. CHRONIC OVEREXPOSURE: PROLONGED
BREATHING OF VAPORS CAN CAUSE DIZZINESS, NAUSEA AND HEADACHE.
REPEATED CONTACT CAN CAUSE DEFATTING AND DERMATITIS.
Effects of Overexposure:SEE HEALTH HAZARDS.

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. CALL A PHYSICIAN. EYE CONTACT: FLUSH IMMEDIATELY
WITH LARGE VOLUMES OF WATER FOR AT LEAST 15 MINUTES. TAKE TO A
PHYSICIAN FOR MEDICAL TREATMENT. SKIN CONTACT: WASH AFFECTED AREA
WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. CONSULT A
PHYSICIAN IF IRRITATION PERSISTS. INGESTION: DRINK 1 OR 2 GLASSES
OF WATER TO DILUTE. DO NOT INDUCE VOMITING. ASPIRATION OF MATERIAL
INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.

Flash Point Method:TCC
Flash Point:>93.3C, 200.F
Extinguishing Media:MEDIA SUITABLE FOR SURROUNDING FIRE .
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:DOT CLASSIFICATION - PAINT (NOT
REGULATED).

Spill Release Procedures:ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL AND PICK UP WITH SHOVEL.
ELIMINATE ALL IGNITION SOURCES (FLARES, FLAMES INCLUDING PILOT
LIGHTS, ELECTRICAL SPARKS). STO P SPILL AT SOURCE.

Handling and Storage Precautions:PRACTICE REASONABLE CARE AND
CLEANLINESS. DO NOT STORE OR USE NEAR HEAT, SPARKS OR OPEN FLAME.
Other Precautions:AVOID GROSS CONTAMINATION OF SKIN. WASH OFF WITH SOAP
AND WATER.

Respiratory Protection:NIOSH APPROVED ORGANIC VAPOR CARTRIDGE OR
RESPIRATOR DESIGNED TO REMOVE COMBINATION OF PARTICULATES AND VAPOR
WHERE CONCENTRATIONS ARE ENCOUNTERED.
Ventilation:LOCAL EXHAUST CAPABLE OF MINIMIZING VAPOR CONCENTRATIONS.
USE WITH ADEQUATE VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH AND DELUGE SHOWER .
Supplemental Safety and Health
PHYSICAL DATA: WEIGHT/GALLON @ 77F: 8.33 LBS.

Spec Gravity:0.998
Percent Volatiles by Volume:NONE

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:AVOID CONTACT WITH STRONG OXIDIZING AGENTS
OR ELEVATED TEMPERATURES.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DO NOT CLOSE
CONTAINERS TIGHTLY AS GASSING MAY DEVELOP IN SOME PRODUCTS.
CAREFULLY INCINERATE OR USE SANITARY LAND FILL IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATI ONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Transport Information:CORROSIVE LIQUID, NOS (DIMETHYLAMINOETHANOL);
CORROSIVE MATERIAL, UN1760.

Federal Regulatory Information:OSHA: CORROSIVE. THIS CHEMICAL IS
REPORTED ON UNITED STATES ENVIRONMENTAL PROTECTION AGENCY TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
State Regulatory Information:AS OF THE DATE ON WHICH THIS MATERIAL
SAFETY DATA SHEET WAS PREPARED, THIS CHEMICAL IS NOT LISTED UNDER
CALIFORNIA PROPOSITION 65. THIS CHEMICAL IS LISTED AS A "HAZARDOUS
SUBSTANCE: UNDER THE PENNSYL VANIA RIGHT TO KNOW ACT. "